4x4Wire Trail Talk Forums: Jeep, Toyota, Mitsubishi, Pajero, Isuzu, Kia, 4WD, 4x4, SUV, Off-Road and OutdoorWire Forums

4x4Wire TrailTalk Forums Index

4x4Wire Mitsubishi Trail Talk Forums

More Mitsubishi on 4x4Wire: 4x4Wire Mitsubishi Section | Mitsubishi Tech
4x4Wire TrailTalk Mitsubishi Forums: Mitsubishi 4x4 and SUV Tech | Mitsubishi Diesels | Mitsubishi Archives

You are not logged in. [Login] Main Index · Search · Active Topics
New user · Who's Online · FAQ · Calendar

Mitsubishi Forums >> Mitsubishi Diesels
Previous thread Previous   View all threads Index   Next thread Next   Flat Mode Flat  

pmontero
Roll Me Over


Reged: 07/12/01
Posts: 3167
Loc: Peachtree City, GA USA
Re: Ranger - Montero Diesel Swap thread
      06/16/12 11:08 AM

I just finished getting the oil pressure gauge working on the Montero diesel. I used the stock '87 Montero 2.6 gas oil pressure gauge unit (NAPA Echlin OP6087) with a 1/8" NPT Female to 1/4" NPT Male bushing. The Ford Ranger diesel engine had an oil pressure switch in it that is 1/4" NPT instead of the Montero's 1/8" NPT. So here's my gauge configuration:

Speedometer - stock gas. This just worked since it was already hooked up and I reused the stock gas manual transmission.

Tachometer - I bought a Dakota Diesel DSL-1D Tach converter and hooked it up to the Hall effect sensor off of the diesel injection pump and hooked it to the stock gas tachometer on the Montero.

Fuel - I reused the stock gas Montero tank and sender. This just worked once I hooked it up.

Voltage - I used the stock Montero Gas alternator wiring harness on a Montero 3.0 V6 gas alternator. (shares the same harness with the 2.6 gas motor) When I hooked it up, the voltmeter worked.

Temperature - I used the stock temp sender that was in the Ford Ranger diesel. It has two blades so I hooked the wire for the Montero temp gauge to one of the blades of the sender. This worked but I think the gauge and sender don't match for calibration. It looks like the truck is running hot on the gauge but it's at 190*F. which is normal operating temp for the Ford Ranger diesel engine. I may see if I can use the stock Montero temp sender with a bushing adapter so it will screw into threads in the diesel engine and hopefully read in the middle? What is normal operating temp for a 2.6 gas motor?

I need to figure out how to wire the EGR light in the gauge cluster so it's not always on, rewire my glow plugs to a relay, install the straight exhaust and replace the clutch master and slave cylinders. (they are weak from sitting)

-Pmontero

--------------------
'87 Montero Diesel
'98 Porsche Boxster Electric
and more...
Greasology
NotPetroleum

Post Extras Print Post   Remind Me!     Notify Moderator


Entire topic
Subject Posted by Posted on
* Ranger - Montero Diesel Swap thread pmontero 02/20/07 09:26 PM
. * * Re: Ranger - Montero Diesel Swap thread kcyule   12/02/07 08:21 AM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/02/07 05:27 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/12/07 05:18 PM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   12/18/07 10:30 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/19/07 02:55 AM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   12/19/07 08:33 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/20/07 02:41 AM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   12/25/07 02:56 AM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/26/07 01:17 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/26/07 01:30 PM
. * * Re: Ranger - Montero Diesel Swap thread dgh   01/01/08 08:45 AM
. * * Re: Ranger - Montero Diesel Swap thread MarkG   01/01/08 06:15 PM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   01/01/08 07:47 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   01/04/08 09:03 PM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   01/12/08 08:49 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   01/21/08 12:36 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   02/01/08 02:57 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   02/01/08 05:13 PM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   02/03/08 06:40 PM
. * * Re: Ranger - Montero Diesel Swap thread gmac   03/02/08 10:58 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   03/10/08 12:00 PM
. * * Re: Ranger - Montero Diesel Swap thread modgishi   05/07/08 07:18 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   05/07/08 10:25 PM
. * * Re: Ranger - Montero Diesel Swap thread modgishi   05/08/08 08:38 AM
. * * Re: Ranger - Montero Diesel Swap thread michigandon   05/12/08 03:35 AM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   05/13/08 02:06 PM
. * * Re: Ranger - Montero Diesel Swap thread modgishi   05/19/08 01:45 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   05/20/08 12:23 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   12/27/08 06:49 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   12/28/08 02:03 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   03/02/09 12:11 PM
. * * Re: Ranger - Montero Diesel Swap thread JeffatTireBalls   07/25/09 09:37 PM
. * * Re: Ranger - Montero Diesel Swap thread torquemonster   07/26/09 01:40 PM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   01/02/09 08:40 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   12/28/08 04:14 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   12/28/08 07:16 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   03/08/08 08:45 AM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   02/01/08 06:17 PM
. * * Re: Ranger - Montero Diesel Swap thread lordtrunks   02/01/08 08:24 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   12/29/07 12:44 PM
. * * Re: Ranger - Montero Diesel Swap thread metalfaced   12/31/07 12:42 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/18/07 02:05 PM
. * * Re: Ranger - Montero Diesel Swap thread NathanC   12/18/07 02:08 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   12/18/07 04:20 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/20/07 09:45 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/20/07 09:54 PM
. * * Re: Ranger - Montero Diesel Swap thread Boertjie   02/21/07 01:32 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/21/07 08:38 AM
. * * Re: Ranger - Montero Diesel Swap thread MarkG   02/21/07 11:39 AM
. * * Re: Ranger - Montero Diesel Swap thread dgh   12/30/07 12:03 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   02/22/07 12:49 PM
. * * Re: Ranger - Montero Diesel Swap thread guzzilapd   03/09/07 05:39 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   03/10/07 02:41 PM
. * * Re: Ranger - Montero Diesel Swap thread stevegreasecar   06/15/07 02:11 AM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   06/29/07 02:19 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   07/16/07 04:53 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   07/16/07 10:07 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   07/18/07 03:19 AM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   08/12/07 02:01 PM
. * * Re: Ranger - Montero Diesel Swap thread redbull   08/12/07 02:48 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   08/13/07 03:03 PM
. * * Re: Ranger - Montero Diesel Swap thread hazy_daze   08/13/07 05:47 PM
. * * Re: Ranger - Montero Diesel Swap thread PHILModerator   08/13/07 09:09 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   08/16/07 12:20 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   03/14/07 05:01 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   05/27/07 11:46 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   05/29/07 03:21 AM
. * * Re: Ranger - Montero Diesel Swap thread lordtrunks   05/29/07 06:55 AM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   05/29/07 11:26 AM
. * * Re: Ranger - Montero Diesel Swap thread PHILModerator   02/21/07 08:15 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/21/07 09:37 PM
. * * Re: Ranger - Montero Diesel Swap thread lordtrunks   02/24/07 08:40 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/24/07 09:39 AM
. * * Re: Ranger - Montero Diesel Swap thread Macka   02/24/07 10:12 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/24/07 01:44 PM
. * * Re: Ranger - Montero Diesel Swap thread lordtrunks   02/24/07 03:31 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/25/07 01:55 PM
. * * Re: Ranger - Montero Diesel Swap thread torquemonster   02/25/07 07:45 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/27/07 07:02 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/28/07 05:26 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   09/16/07 10:08 AM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   09/22/07 12:22 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   09/22/07 04:42 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   09/29/07 12:19 PM
. * * Re: Ranger - Montero Diesel Swap thread rockrenegade   11/10/07 05:36 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   10/03/07 05:40 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   10/04/07 07:57 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   10/14/07 05:39 PM
. * * Re: Ranger - Montero Diesel Swap thread PA_JERO   10/14/07 06:44 PM
. * * Re: Ranger - Montero Diesel Swap thread DonM   10/14/07 10:12 PM
. * * Re: Ranger - Montero Diesel Swap thread PA_JERO   10/17/07 09:12 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   10/21/07 08:49 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   10/22/07 01:28 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   10/23/07 03:54 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   11/03/07 10:28 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   11/04/07 03:16 PM
. * * Re: Ranger - Montero Diesel Swap thread PA_JERO   11/05/07 11:08 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   11/06/07 02:46 AM
. * * Re: Ranger - Montero Diesel Swap thread 89Diesel   11/06/07 02:36 PM
. * * Re: Ranger - Montero Diesel Swap thread PA_JERO   11/06/07 10:56 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   11/07/07 12:26 AM
. * * Re: Ranger - Montero Diesel Swap thread 89Diesel   11/07/07 10:07 AM
. * * Re: Ranger - Montero Diesel Swap thread lordtrunks   11/07/07 04:52 PM
. * * Re: Ranger - Montero Diesel Swap thread 89Diesel   11/07/07 05:12 PM
. * * Re: Ranger - Montero Diesel Swap thread rockrenegade   11/14/07 04:56 AM
. * * Re: Ranger - Montero Diesel Swap thread PA_JERO   11/09/07 09:35 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   11/10/07 02:04 PM
. * * Re: Ranger - Montero Diesel Swap thread samwe   10/22/07 02:21 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   03/05/07 01:20 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/20/07 09:37 PM
. * * Re: Ranger - Montero Diesel Swap thread tony007   01/29/09 10:14 PM
. * * Re: Ranger - Montero Diesel Swap thread dudly   02/02/10 11:49 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/03/10 11:15 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/04/10 08:35 AM
. * * Re: Ranger - Montero Diesel Swap thread Macka   04/04/10 12:50 PM
. * * Re: Ranger - Montero Diesel Swap thread PHILModerator   04/04/10 12:57 PM
. * * Re: Ranger - Montero Diesel Swap thread Macka   04/04/10 01:14 PM
. * * Re: Ranger - Montero Diesel Swap thread Mitsulvr   04/04/10 04:33 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/04/10 09:52 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/07/10 09:01 AM
. * * Re: Ranger - Montero Diesel Swap thread torquemonster   04/07/10 07:03 PM
. * * Re: Ranger - Montero Diesel Swap thread dudly   04/07/10 11:51 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/12/10 08:30 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/12/10 08:39 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/13/10 08:46 PM
. * * Re: Ranger - Montero Diesel Swap thread dudly   04/14/10 02:21 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/14/10 07:39 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/17/10 01:27 PM
. * * Re: Ranger - Montero Diesel Swap thread dylanb   05/03/10 01:45 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   05/03/10 03:06 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   05/08/10 10:23 PM
. * * Re: Ranger - Montero Diesel Swap thread dudly   05/09/10 12:18 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   05/10/10 08:45 AM
. * * Re: Ranger - Montero Diesel Swap thread dudly   05/10/10 09:01 AM
. * * Re: Ranger - Montero Diesel Swap thread dudly   05/12/10 10:41 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   05/12/10 07:42 PM
. * * Re: Ranger - Montero Diesel Swap thread dudly   05/12/10 08:42 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   05/15/10 04:42 PM
. * * Re: Ranger - Montero Diesel Swap thread dudly   05/24/10 12:33 AM
. * * Re: Ranger - Montero Diesel Swap thread spencevans   08/09/10 11:51 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   08/14/10 06:59 PM
. * * Re: Ranger - Montero Diesel Swap thread spencevans   08/17/10 04:37 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   08/25/10 08:02 PM
. * * Re: Ranger - Montero Diesel Swap thread spencevans   08/26/10 07:36 PM
. * * Re: Ranger - Montero Diesel Swap thread JeffatTireBalls   11/21/10 12:02 PM
. * * Re: Ranger - Montero Diesel Swap thread JeffatTireBalls   12/09/10 10:04 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   12/15/10 09:33 PM
. * * Re: Ranger - Montero Diesel Swap thread JeffatTireBalls   04/22/11 06:18 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   06/12/11 02:46 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   10/14/11 10:58 PM
. * * Re: Ranger - Montero Diesel Swap thread MontyMcV   10/15/11 05:47 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   10/15/11 11:42 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   01/28/12 05:27 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   01/28/12 07:28 PM
. * * Re: Ranger - Montero Diesel Swap thread redbull   01/30/12 02:22 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/21/12 08:19 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   02/21/12 10:13 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   02/22/12 08:53 AM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   02/22/12 01:21 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   03/03/12 01:10 AM
. * * Re: Ranger - Montero Diesel Swap thread JeffatTireBalls   03/03/12 09:39 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   06/16/12 11:08 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   03/17/13 09:12 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   03/18/13 07:07 AM
. * * Re: Ranger - Montero Diesel Swap thread JeffatTireBalls   03/18/13 08:37 AM
. * * Re: Ranger - Montero Diesel Swap thread MarkG   02/22/12 10:10 AM
. * * Re: Ranger - Montero Diesel Swap thread MarkG   10/14/11 11:14 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   10/15/11 08:00 AM
. * * Re: Ranger - Montero Diesel Swap thread PHILModerator   10/15/11 01:16 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/17/10 01:35 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/17/10 02:17 PM
. * * Re: Ranger - Montero Diesel Swap thread dudly   04/20/10 01:27 AM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   04/20/10 05:33 AM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/20/10 11:26 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/23/10 09:35 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/18/10 07:44 PM
. * * Re: Ranger - Montero Diesel Swap thread pmontero   04/19/10 08:09 AM
. * * Re: Ranger - Montero Diesel Swap thread ericlerouge   04/19/10 09:34 PM
. * * Re: Ranger - Montero Diesel Swap thread LandRaiderModerator   04/07/10 03:42 PM

Extra information
0 registered and 6 anonymous users are browsing this forum.

Moderator:  LandRaider, PHIL 



Forum Permissions
      You cannot start new topics
      You cannot reply to topics
      HTML is disabled
      UBBCode is enabled

Rating:
Thread views: 51167

Rate this thread

Jump to
4x4Wire.com | OutdoorWire | MUIRNet News | 4x4Voice | 4x4Wire on FaceBook
About 4x4Wire | Advertiser's Guide |
This site and all original materials contained herein are Copyright 1999 - 2013 by OutdoorWire, Inc. -- All Rights Reserved.
The use of this website, OutdoorWire, or any of its publications or services is subject to the terms of use agreement.
You may link freely to this site, but no further use is allowed without the express written permission of the owner of this material.
All corporate trademarks are the property of their respective owners.
This publication and OutdoorWire, Inc. assume no liability for your use of the material contained within this site.
OutdoorWire, 4x4Wire, SUVWire, JeepWire, MUIRNet-News, and 4x4Voice are all trademarks and publications of OutdoorWire, Inc.

Contact 4x4Wire | Privacy statement 4x4Wire TrailTalk Forums

Powered by UBB.threads™ 6.5.5

Generated in 0.057 seconds in which 0.014 seconds were spent on a total of 11 queries. Zlib compression enabled.