4x4Wire Trail Talk Forums: Jeep, Toyota, Mitsubishi, Pajero, Isuzu, Kia, 4WD, 4x4, SUV, Off-Road and OutdoorWire Forums





*4x4Wire TrailTalk Forums Index* 4x4Wire \| OutdoorWire \| MUIRNet News \| 4x4Voice \| 4x4Wire on FaceBook Galleries \| Offtopic Chat \| Garage Sale \| Items Wanted \| Vendors \| Trailrides and Events \| Recreational Access and Landuse

4x4Wire Mitsubishi Trail Talk Forums

More Mitsubishi on 4x4Wire: 4x4Wire Mitsubishi Section | Mitsubishi Tech
4x4Wire TrailTalk Mitsubishi Forums: Mitsubishi 4x4 and SUV Tech | Mitsubishi Diesels | Mitsubishi Archives

You are not logged in. [Login]

Main Index · Search · Active Topics
New user · Who's Online · FAQ · Calendar

Mitsubishi Forums >> Mitsubishi Diesels

pmontero
Roll Me Over

Reged: 07/12/01
Posts: 3167
Loc: Peachtree City, GA USA

Re: Ranger - Montero Diesel Swap thread
04/18/10 07:44 PM

Had some quality time with the engine today. I started off the morning at the junkyard and scored two different Mitsubishi power steering reservoirs. The one on the left is from a 4 cylinder Mirage. The one on the right is from a V6 Diamante. I have two mounting options now based on the position of the mount.

There was a '90 Montero that lured me to the yard but it had been pulled from a muddy river. Totally trashed. It had a nice bouncy seat but I'm sure the piston is shot.

I pulled the Ranger oil pan from the motor and the crankshaft looks really clean.

There was a piece of foil from the cover on an oil container stuck on the oil pickup screen. Yikes! I'm very careful about removing the foil so this may have happened before I owned it. That was the only thing other than oil on the screen. (the engine only has 70k miles on it)

I scraped the block clean with a razor, cleaned both surfaces with acetone and then prepped the gasket with sealant on both sides. I also coated joints on the block where the oil pump and rear crankshaft housing meet the block. I used a Felpro paper oil pan gasket with Permatex Ultra Black sealant. I tightened the oil pan bolts finger tight, waited an hour for the Permatex to set and then tightened them with a torque-wrench to 5.5 ft/lbs. per the Service Manual.

My engine is looking much more "Pajero-ish" now!!

-Pmontero

--------------------
'87 Montero Diesel
'98 Porsche Boxster Electric
and more...
Greasology
NotPetroleum

Post Extras

Print Post

Remind Me!

Notify Moderator

Entire topic
Subject	Posted by	Posted on
Ranger - Montero Diesel Swap thread	pmontero	02/20/07 09:26 PM
Re: Ranger - Montero Diesel Swap thread	kcyule	12/02/07 08:21 AM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/02/07 05:27 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/12/07 05:18 PM
Re: Ranger - Montero Diesel Swap thread	metalfaced	12/18/07 10:30 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/19/07 02:55 AM
Re: Ranger - Montero Diesel Swap thread	metalfaced	12/19/07 08:33 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/20/07 02:41 AM
Re: Ranger - Montero Diesel Swap thread	metalfaced	12/25/07 02:56 AM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/26/07 01:17 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/26/07 01:30 PM
Re: Ranger - Montero Diesel Swap thread	dgh	01/01/08 08:45 AM
Re: Ranger - Montero Diesel Swap thread	MarkG	01/01/08 06:15 PM
Re: Ranger - Montero Diesel Swap thread	metalfaced	01/01/08 07:47 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	01/04/08 09:03 PM
Re: Ranger - Montero Diesel Swap thread	metalfaced	01/12/08 08:49 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	01/21/08 12:36 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	02/01/08 02:57 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	02/01/08 05:13 PM
Re: Ranger - Montero Diesel Swap thread	metalfaced	02/03/08 06:40 PM
Re: Ranger - Montero Diesel Swap thread	gmac	03/02/08 10:58 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	03/10/08 12:00 PM
Re: Ranger - Montero Diesel Swap thread	modgishi	05/07/08 07:18 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	05/07/08 10:25 PM
Re: Ranger - Montero Diesel Swap thread	modgishi	05/08/08 08:38 AM
Re: Ranger - Montero Diesel Swap thread	michigandon	05/12/08 03:35 AM
Re: Ranger - Montero Diesel Swap thread	LandRaider	05/13/08 02:06 PM
Re: Ranger - Montero Diesel Swap thread	modgishi	05/19/08 01:45 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	05/20/08 12:23 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	12/27/08 06:49 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	12/28/08 02:03 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	03/02/09 12:11 PM
Re: Ranger - Montero Diesel Swap thread	JeffatTireBalls	07/25/09 09:37 PM
Re: Ranger - Montero Diesel Swap thread	torquemonster	07/26/09 01:40 PM
Re: Ranger - Montero Diesel Swap thread	metalfaced	01/02/09 08:40 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	12/28/08 04:14 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	12/28/08 07:16 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	03/08/08 08:45 AM
Re: Ranger - Montero Diesel Swap thread	dylanb	02/01/08 06:17 PM
Re: Ranger - Montero Diesel Swap thread	lordtrunks	02/01/08 08:24 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	12/29/07 12:44 PM
Re: Ranger - Montero Diesel Swap thread	metalfaced	12/31/07 12:42 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/18/07 02:05 PM
Re: Ranger - Montero Diesel Swap thread	NathanC	12/18/07 02:08 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	12/18/07 04:20 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/20/07 09:45 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/20/07 09:54 PM
Re: Ranger - Montero Diesel Swap thread	Boertjie	02/21/07 01:32 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/21/07 08:38 AM
Re: Ranger - Montero Diesel Swap thread	MarkG	02/21/07 11:39 AM
Re: Ranger - Montero Diesel Swap thread	dgh	12/30/07 12:03 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	02/22/07 12:49 PM
Re: Ranger - Montero Diesel Swap thread	guzzilapd	03/09/07 05:39 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	03/10/07 02:41 PM
Re: Ranger - Montero Diesel Swap thread	stevegreasecar	06/15/07 02:11 AM
Re: Ranger - Montero Diesel Swap thread	dylanb	06/29/07 02:19 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	07/16/07 04:53 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	07/16/07 10:07 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	07/18/07 03:19 AM
Re: Ranger - Montero Diesel Swap thread	dylanb	08/12/07 02:01 PM
Re: Ranger - Montero Diesel Swap thread	redbull	08/12/07 02:48 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	08/13/07 03:03 PM
Re: Ranger - Montero Diesel Swap thread	hazy_daze	08/13/07 05:47 PM
Re: Ranger - Montero Diesel Swap thread	PHIL	08/13/07 09:09 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	08/16/07 12:20 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	03/14/07 05:01 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	05/27/07 11:46 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	05/29/07 03:21 AM
Re: Ranger - Montero Diesel Swap thread	lordtrunks	05/29/07 06:55 AM
Re: Ranger - Montero Diesel Swap thread	dylanb	05/29/07 11:26 AM
Re: Ranger - Montero Diesel Swap thread	PHIL	02/21/07 08:15 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/21/07 09:37 PM
Re: Ranger - Montero Diesel Swap thread	lordtrunks	02/24/07 08:40 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/24/07 09:39 AM
Re: Ranger - Montero Diesel Swap thread	Macka	02/24/07 10:12 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/24/07 01:44 PM
Re: Ranger - Montero Diesel Swap thread	lordtrunks	02/24/07 03:31 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/25/07 01:55 PM
Re: Ranger - Montero Diesel Swap thread	torquemonster	02/25/07 07:45 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/27/07 07:02 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/28/07 05:26 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	09/16/07 10:08 AM
Re: Ranger - Montero Diesel Swap thread	dylanb	09/22/07 12:22 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	09/22/07 04:42 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	09/29/07 12:19 PM
Re: Ranger - Montero Diesel Swap thread	rockrenegade	11/10/07 05:36 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	10/03/07 05:40 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	10/04/07 07:57 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	10/14/07 05:39 PM
Re: Ranger - Montero Diesel Swap thread	PA_JERO	10/14/07 06:44 PM
Re: Ranger - Montero Diesel Swap thread	DonM	10/14/07 10:12 PM
Re: Ranger - Montero Diesel Swap thread	PA_JERO	10/17/07 09:12 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	10/21/07 08:49 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	10/22/07 01:28 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	10/23/07 03:54 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	11/03/07 10:28 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	11/04/07 03:16 PM
Re: Ranger - Montero Diesel Swap thread	PA_JERO	11/05/07 11:08 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	11/06/07 02:46 AM
Re: Ranger - Montero Diesel Swap thread	89Diesel	11/06/07 02:36 PM
Re: Ranger - Montero Diesel Swap thread	PA_JERO	11/06/07 10:56 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	11/07/07 12:26 AM
Re: Ranger - Montero Diesel Swap thread	89Diesel	11/07/07 10:07 AM
Re: Ranger - Montero Diesel Swap thread	lordtrunks	11/07/07 04:52 PM
Re: Ranger - Montero Diesel Swap thread	89Diesel	11/07/07 05:12 PM
Re: Ranger - Montero Diesel Swap thread	rockrenegade	11/14/07 04:56 AM
Re: Ranger - Montero Diesel Swap thread	PA_JERO	11/09/07 09:35 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	11/10/07 02:04 PM
Re: Ranger - Montero Diesel Swap thread	samwe	10/22/07 02:21 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	03/05/07 01:20 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/20/07 09:37 PM
Re: Ranger - Montero Diesel Swap thread	tony007	01/29/09 10:14 PM
Re: Ranger - Montero Diesel Swap thread	dudly	02/02/10 11:49 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/03/10 11:15 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/04/10 08:35 AM
Re: Ranger - Montero Diesel Swap thread	Macka	04/04/10 12:50 PM
Re: Ranger - Montero Diesel Swap thread	PHIL	04/04/10 12:57 PM
Re: Ranger - Montero Diesel Swap thread	Macka	04/04/10 01:14 PM
Re: Ranger - Montero Diesel Swap thread	Mitsulvr	04/04/10 04:33 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/04/10 09:52 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/07/10 09:01 AM
Re: Ranger - Montero Diesel Swap thread	torquemonster	04/07/10 07:03 PM
Re: Ranger - Montero Diesel Swap thread	dudly	04/07/10 11:51 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/12/10 08:30 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/12/10 08:39 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/13/10 08:46 PM
Re: Ranger - Montero Diesel Swap thread	dudly	04/14/10 02:21 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/14/10 07:39 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/17/10 01:27 PM
Re: Ranger - Montero Diesel Swap thread	dylanb	05/03/10 01:45 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	05/03/10 03:06 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	05/08/10 10:23 PM
Re: Ranger - Montero Diesel Swap thread	dudly	05/09/10 12:18 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	05/10/10 08:45 AM
Re: Ranger - Montero Diesel Swap thread	dudly	05/10/10 09:01 AM
Re: Ranger - Montero Diesel Swap thread	dudly	05/12/10 10:41 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	05/12/10 07:42 PM
Re: Ranger - Montero Diesel Swap thread	dudly	05/12/10 08:42 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	05/15/10 04:42 PM
Re: Ranger - Montero Diesel Swap thread	dudly	05/24/10 12:33 AM
Re: Ranger - Montero Diesel Swap thread	spencevans	08/09/10 11:51 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	08/14/10 06:59 PM
Re: Ranger - Montero Diesel Swap thread	spencevans	08/17/10 04:37 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	08/25/10 08:02 PM
Re: Ranger - Montero Diesel Swap thread	spencevans	08/26/10 07:36 PM
Re: Ranger - Montero Diesel Swap thread	JeffatTireBalls	11/21/10 12:02 PM
Re: Ranger - Montero Diesel Swap thread	JeffatTireBalls	12/09/10 10:04 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	12/15/10 09:33 PM
Re: Ranger - Montero Diesel Swap thread	JeffatTireBalls	04/22/11 06:18 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	06/12/11 02:46 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	10/14/11 10:58 PM
Re: Ranger - Montero Diesel Swap thread	MontyMcV	10/15/11 05:47 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	10/15/11 11:42 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	01/28/12 05:27 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	01/28/12 07:28 PM
Re: Ranger - Montero Diesel Swap thread	redbull	01/30/12 02:22 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/21/12 08:19 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	02/21/12 10:13 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	02/22/12 08:53 AM
Re: Ranger - Montero Diesel Swap thread	LandRaider	02/22/12 01:21 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	03/03/12 01:10 AM
Re: Ranger - Montero Diesel Swap thread	JeffatTireBalls	03/03/12 09:39 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	06/16/12 11:08 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	03/17/13 09:12 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	03/18/13 07:07 AM
Re: Ranger - Montero Diesel Swap thread	JeffatTireBalls	03/18/13 08:37 AM
Re: Ranger - Montero Diesel Swap thread	MarkG	02/22/12 10:10 AM
Re: Ranger - Montero Diesel Swap thread	MarkG	10/14/11 11:14 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	10/15/11 08:00 AM
Re: Ranger - Montero Diesel Swap thread	PHIL	10/15/11 01:16 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/17/10 01:35 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/17/10 02:17 PM
Re: Ranger - Montero Diesel Swap thread	dudly	04/20/10 01:27 AM
Re: Ranger - Montero Diesel Swap thread	LandRaider	04/20/10 05:33 AM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/20/10 11:26 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/23/10 09:35 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/18/10 07:44 PM
Re: Ranger - Montero Diesel Swap thread	pmontero	04/19/10 08:09 AM
Re: Ranger - Montero Diesel Swap thread	ericlerouge	04/19/10 09:34 PM
Re: Ranger - Montero Diesel Swap thread	LandRaider	04/07/10 03:42 PM

Extra information

0 registered and 4 anonymous users are browsing this forum.

Moderator: LandRaider, PHIL

Forum Permissions
      You cannot start new topics
      You cannot reply to topics
      HTML is disabled
      UBBCode is enabled

Rating:
Thread views: 50632

Jump to

4x4Wire.com | OutdoorWire | MUIRNet News | 4x4Voice | 4x4Wire on FaceBook
About 4x4Wire | Advertiser's Guide |

This site and all original materials contained herein are Copyright 1999 - 2013 by OutdoorWire, Inc. -- All Rights Reserved.
The use of this website, OutdoorWire, or any of its publications or services is subject to the terms of use agreement.
You may link freely to this site, but no further use is allowed without the express written permission of the owner of this material.
All corporate trademarks are the property of their respective owners.
This publication and OutdoorWire, Inc. assume no liability for your use of the material contained within this site.
OutdoorWire, 4x4Wire, SUVWire, JeepWire, MUIRNet-News, and 4x4Voice are all trademarks and publications of OutdoorWire, Inc.

Contact 4x4Wire | Privacy statement

4x4Wire TrailTalk Forums

Powered by UBB.threads™ 6.5.5

Generated in 0.042 seconds in which 0.01 seconds were spent on a total of 11 queries. Zlib compression enabled.