4x4Wire's TrailTalk Forums: how many mile on your montero or mighty max

Yea, it's getting up there. Don't do anything special - the spark plugs and wires haven't been changed in five years.:-) Mobil 1 10-30 full synthetic (green cap) in the engine. The big Mitsu oil filter from Carquest. BG MOA every oil change. I change oil every 8-9k. Clean the air filter about once a year. Amsoil synthetic in the trans and t-case. I was running redline in the diffs but I switched the front to Amsoil when I installed the new ARB diff cover last month and I'll do the back when the weather warms up. $9 a quart Amsoil vs. $20 a quart Redline. Mmmmm. Hard choice.:-)

87Montero:

That's what I was trying to figure out a couple days ago. The SAS was finished beginning of May 2001 and I think I had about 115K on my Sport when the conversion was done. Have to check but I know that's real close 'cause I'd just had my first timing belt replacment the year before and I was a bit overdue on that. So, most of the miliage is on the SAS.

Had to replace a rear shock that got hit with a log or something the year before last; one of the stupid Ford spring pads (cracked); I've changed out all the tie-rod ends twice and the track bar bushing four or five times. Oh, and three Heim joints - until I found out that the idiots at the speed shop I was buying from was selling me the cheap joints and charging me for the good ones. Grrr!!! Haven't broken one of those in a couple years now. And, I finally had to replace the original front axle u-joints last fall. Innumerable rear diff u-joints - 'cause I guess I still don't kwow where my rear diff is in relation to the GIANT ROCK I just drove over.:-( OH, and I switched to the Powerslot rotors and Hawk pads all the way around; they brake better and look like they'll last longer than the Napa rotors and pads I was using.

Only thing I've ever broken (keeping fingers crossed) 'wheeling was the Heim joint on my track bar and that was because there wasn't enough clearance around the Heim joint after the suspension was broke in. Fixed that with a Rotozip and a grider wheel several years ago. Figure if I didn't break it on Flat Pass Road June before last it's good.:-)

And, I'm on my third or fourth set of leaf springs - axle wrap from the spring-over, WAY overloaded vehicle, deeper t-case gears and the super sticky sandstone in Moab. The new set is completely redesigned with torque leafs and a different rate. Keeping fingers crossed with these as well.:-) Managed to bust both the left and right side primary leaves on Elephant Hill in November. Made for an interesting drive back to Denver.:-(

Anyway, can't imagine how much Mitsu replacement parts would have cost in that time if I would have stuck with the IFS.

Edward

--------------------
'97 Montero Sport LS 5-Speed 3.5L conversion
SAS Dana 44s & ARBs, 35" Yoko Geolandar M/Ts
NP231 B4R doubler/Terra Low231/RP 5.38 228:1
'03 Montero Sport Limited AWD
'97 Montero Sport LS 5-Speed 3-link/SAS project

Post Extras

4x4Wire TrailTalk Forums Index

4x4Wire Mitsubishi Trail Talk Forums





*4x4Wire TrailTalk Forums Index* 4x4Wire \| OutdoorWire \| MUIRNet News \| 4x4Voice \| 4x4Wire on FaceBook Galleries \| Offtopic Chat \| Garage Sale \| Items Wanted \| Vendors \| Trailrides and Events \| Recreational Access and Landuse